Utilization of PDAM Sedimentation Sludge as a Multi Soil Layering (MSL) Substance in the Degradation of Liquid Waste Contaminants from the Tofu Industry

Ama Mullah, Nur Aida, Aisya Syakira, Abd Mujahid Hamdan

Abstract


Multi Soil Layering (MSL) is a procedure for treating liquid waste that employs soil as its primary medium. In addition to soil as the primary medium, it can also use sedimentation waste (PDAM) as an alternative. This study included two variations: HLR value variations and HRT value variations. The results indicated that the HLR values were 11.48 L/m2/hour, 4.76 L/m2/hour, and 2.48 L/m2/hour, with 2.48 L/m2/hour exhibiting the highest level of effectiveness. The pH and DO values changed to 7.4 and 19.5 mg/L, respectively, and the TSS value effectiveness reached 76.32%, the TDS value degradation reached 75.21%, the turbidity degradation reached 99.69%, and the COD degradation reached 99.66. At the HRT values of 4 hours, 6 hours, 8 hours, 10 hours, and 12 hours, the effectiveness level of the greatest HRT variation occurred at 12 hours, where the value of changes in pH and DO became 19.5 mg/L and became 7.5, and the effectiveness COD value degradation reached 98.95%, BOD value degradation reached 51.11%, and TSS degradation reached 73.5%. The obtained results indicate that the MSL method with PDAM sedimentation waste material is capable of reducing pollutant levels in the tofu manufacturing industry.


Keywords


Tofu industrial wastewater, Multi Soil Layering, PDAM sedimentation sludge

Full Text:

PDF

References


Armi. (2019). Pemanfaatan Limbah Cair Industri Tahu Dengan Menggunakan Acetobakter Xylinnataum Menjadi Nata De Soya Dan Masa Inkubasi Terhadap Karakteristik. Jurnal Serambi Ekonomi dan Bisnis, 1(1), 27–34.

Aba, R. P., Mugani, R., Hejjaj, A., Fraissinette, N. B. De, Oudra, B., Ouazzani, N., Campos, A., Vasconcelos, V., Carvalho, P. N., dan Mandi, L. (2021). First Report on Cyanotoxin (MC-LR) Removal from Surface Water by Multi-Soil-Layering (MSL) Eco-Technology: Preliminary Results.

Chen, Y. C., dan Pat, H. W. (2021). Comparing natural red soil and irons for removal of phosphorus from wastewater using the multi-soil-layering system and its economic analysis. Journal of Environmental Management, 296(June), 113252.

Haribowo, R., Megah, S., dan Rosita, W. (2019). Efisiensi Sistem Multi Soil Layering Pada Pengolahan Air Limbah Domestik Pada Daerah Perkotaan Padat Penduduk. Jurnal Teknik Pengairan, 10(1), 11–27.

Ho, C. C., dan Wang, P. H. (2017). Efficiency of a multi-soil-layering system on wastewater treatment using environment-friendly filter materials. International Journal of Environmental Research and Public Health, 12(3), 3362–3380.

Hong, Y., Huang, G., An, C., Song, P., Xin, X., Chen, X., Zhang, P., Zhao, Y., dan Zheng, R. (2019). Enhanced nitrogen removal in the treatment of rural domestic sewage using vertical-flow multi-soil-layering systems: Experimental and modeling insights. Journal of Environmental Management, 240(November 2018), 273–284.

Ivontianti, W. D., Sitanggang, E. P. O., dan Rezeki, E. S. (2021). Pengolahan Limbah Cair Lindi Menggunakan Multi Soil Layering (MSL) Bebasis Lumpur PDAM. Jurnal Rekayasa Hijau, 5(3), 228–237.

Ma, Y., Wu, Y., Lee, J. G., He, L., Rother, G., Fameau, A. L., Shelton, W. A., dan Bharti, B. (2020). Adsorption of Fatty Acid Molecules on Amine-Functionalized Silica Nanoparticles: Surface Organization and Foam Stability. Langmuir, 36(14), 3703–3712.

Nugteren, H. W., Butselaar-Orthlieb, V. C. L., dan Izquierdo, M. (2017). High strength geopolymers produced from coal combustion fly ash. Global Nest Journal, 11(2), 155–161.

Karima, N., Ilyas, N. I., dan Ardiatma, D. (2022). Penyisihan BOD dan COD dari Limbah Domestik Dengan Metode Multi Soil Layering ( MSL ). SAINTEK: Sains Dan Teknologi Vol.1, 1(1), 525–532.

Koottatep, T., Suksiri, P., Pussayanavin, T., dan Polprasert, C. (2018). Development of a Novel Multi-soil Layer Constructed Wetland Treating Septic Tank Effluent with Emphasis on Organic and Ammonia Removals. Water, Air, and Soil Pollution, 229(8).

Lakherwal, D. (2017). Adsorption of Heavy Metals. Journa of Environmental Research and Development, 2(October), 41–48.

Latrach, L., Ouazzani, N., Hejjaj, A., Mahi, M., Masunaga, T., dan Mandi, L. (2017). Two-stage vertical flow multi-soil-layering (MSL) technology for efficient removal of coliforms and human pathogens from domestic wastewater in rural areas under arid climate. International Journal of Hygiene and Environmental Health, 221(1), 64–80.

Latrach, L., Ouazzani, N., Masunaga, T., Hejjaj, A., Bouhoum, K., Mahi, M., dan Mandi, L. (2016). Domestic wastewater disinfection by combined treatment using multi-soil-layering system and sand filters (MSL-SF): A laboratory pilot study. Ecological Engineering, 91, 294–301.

Latrach, L., Ouazzani, N., Hejjaj, A., Zouhir, F., Mahi, M., Masunaga, T., dan Mandi, L. (2018). Optimization of hydraulic efficiency and wastewater treatment performances using a new design of vertical flow Multi-Soil-Layering (MSL) technology. Ecological Engineering, 117(March), 140–152.

Purba, M. H. W., Hakim, L., dan Wardhana, M. Y. (2020). Strategi Pengembangan Industri Kecil Tahu Solo Di Desa Punge Blang Cut Kecamatan Meuraxa Kota Banda Aceh. Jurnal Ekonomi Pertanian Dan Agribisnis, 4(4), 1–16.

Ren, S., Song, P., Cheng, H., Liu, C., dan Chen, R. (2022). Enhanced Treatment of Decentralized Domestic Sewage Using Gravity-Flow Multi-Soil-Layering Systems Coupled with Iron-Carbon Microelectrolysis. Sustainability (Switzerland), 14(19).

Song, P., Huang, G., An, C., Shen, J., Zhang, P., Chen, X., Shen, J., Yao, Y., Zheng, R., dan Sun, C. (2018). Treatment of rural domestic wastewater using multi-soil-layering systems: Performance evaluation, factorial analysis and numerical modeling. Science of the Total Environment, 644, 536–546.

Sbahi, S., Ouazzani, N., Latrach, L., Hejjaj, A., dan Mandi, L. (2020). Predicting the concentration of total coliforms in treated rural domestic wastewater by multi-soil-layering (MSL) technology using artificial neural networks. Ecotoxicology and Environmental Safety, 204(August), 111118.

Taouraout, A., Chahlaoui, A., Belghyti, D., Taha, I., Ouarrak, K., dan Sammoudi, R. (2019). Hydraulic load rates effect on the performance of Horizontal Multi-Soil-Layering to treat domestic wastewater in rural areas of Morocco. J. Mater. Environ. Sci, 10(5), 422–430.

Zaman, B., dan Oktiawan, W. (2020). Efficiency of Multi Soil Layering (MSL) System in A Household Scale of Wastewater Treatment Using Environmental Friendly Materials. Sustinere: Journal of Environment and Sustainability, 4(1), 33–42.

Zhao, W., Xie, H., Li, J., Zhang, L., dan Zhao, Y. (2021). Application of alum sludge in wastewater treatment processes: “Science” of reuse and reclamation pathways. Processes, 9(4), 1–12.

Zhou, Q., Sun, H., Jia, L., Zhao, L., dan Wu, W. (2021). Enhanced pollutant removal from rural non-point source wastewater using a two-stage multi-soil-layering system with blended carbon sources: Insights into functional genes, microbial community structure and metabolic function. Chemosphere, 275, 130007.




DOI: http://dx.doi.org/10.22373/p-jpft.v10i1.19715

Refbacks

  • There are currently no refbacks.


Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

INDEXED BY:

OFFICE:

Gedung Fakultas Tarbiyah dan Keguruan, Universitas Islam Negeri Ar-Raniry Banda Aceh. Jalan Syeikh Abdul Rauf, Syiah Kuala, Kopelma Darussalam, Syiah Kuala, Kota Banda Aceh, Aceh, 23111. email: jurnal.phi@ar-raniry.ac.id

Creative Commons License

This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License

View My Stats